Jlg M400 Operator Manual User Manual Page 99
- Page / 108
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
SECTION 6 - GENERAL SPECIFICATIONS & OPERATOR MAINTENANCE
3121644 – JLG Lift – 6-17
Optional On Board Generator
EXHAUST GAS HAZARD. RUN THE GENERATOR IN A WELL VENTILATED AREA ONLY.
WHEN THE GENERATOR ENABLE CONTROL LOCATED IN THE PLATFORM CONTROL BOX
IS IN THE ON POSITION AND THE GROUND EMERGENCY STOP SWITCH IN ON (PULLED
OUT), THE GENERATOR WILL START AUTOMATICALLY WHEN THE BATTERIES REACH A
LOW-CHARGE STATE AUTOMATICALLY CHARGING THE BATTERIES.
NOTE: The engine will automatically shut down under the following
conditions:
High Engine Oil Temperature
Low Engine Oil Pressure
Engine Overspeed
Generator Overvoltage
TO AVOID INJURY FROM AN EXPLOSION, DO NOT SMOKE OR ALLOW SPARKS OR A
FLAME NEAR BATTERY DURING SERVICING. ALWAYS WEAR EYE AND HAND PROTEC-
TION WHEN SERVICING BATTERIES.
Battery Charging (On Board Charger)
1. For maximum battery life:
a. Avoid completely discharging the batteries.
b. Fully charge the batteries each day the machine is used.
c. Charge the batteries at available times between charg-
ing.
d. If applicable, be sure the battery fluid covers the battery
plates before charging, but to avoid overflow, do not
top off the fluid level until charging.
2. To charge the batteries, connect the charger to an appropri-
ate volt source with a 15 amp minimum capacity.
3. The charge cycle is complete when the green 100% charge
light on the battery charger comes on.
- Operation and Safety Manual 1
- FOREWORD 3
- Contact: 5
- Outside USA: 5
- REVISION LOG 6
- TABLE OF CONTENTS 10
- 1.1 GENERAL 11
- 1.2 PRE-OPERATION 11
- Workplace Inspection 12
- Machine Inspection 13
- 1.3 OPERATION 13
- General 13
- Trip and Fall Hazards 14
- Electrocution Hazards 15
- 1-6 – JLG Lift – 3121644 16
- Tipping Hazards 17
- 1-8 – JLG Lift – 3121644 18
- 3121644 – JLG Lift – 1-9 19
- 1-10 – JLG Lift – 3121644 20
- 1.5 MAINTENANCE 21
- Maintenance Hazards 21
- 1-12 – JLG Lift – 3121644 22
- Battery Hazards 23
- 1-14 – JLG Lift – 3121644 24
- 2.1 PERSONNEL TRAINING 25
- Operator Training 25
- Training Supervision 25
- Operator Responsibility 25
- 2-2 – JLG Lift – 3121644 26
- 3121644 – JLG Lift – 2-3 27
- Pre-Start Inspection 28
- Function Check 29
- 2-6 – JLG Lift – 3121644 30
- 3121644 – JLG Lift – 2-7 31
- 2-8 – JLG Lift – 3121644 32
- 3121644 – JLG Lift – 2-9 33
- 2-10 – JLG Lift – 3121644 34
- 3.1 GENERAL 35
- 3.2 CONTROLS AND INDICATORS 35
- Ground Control Station 36
- 3121644 – JLG Lift – 3-3 37
- 3-4 – JLG Lift – 3121644 38
- 3121644 – JLG Lift – 3-5 39
- Platform Station 40
- 3121644 – JLG Lift – 3-7 41
- 3-8 – JLG Lift – 3121644 42
- 3121644 – JLG Lift – 3-9 43
- 3-10 – JLG Lift – 3121644 44
- 3121644 – JLG Lift – 3-11 45
- 3-12 – JLG Lift – 3121644 46
- 3121644 – JLG Lift – 3-13 47
- 3-14 – JLG Lift – 3121644 48
- 3121644 – JLG Lift – 3-15 49
- 3-16 – JLG Lift – 3121644 50
- SECTION 4. MACHINE OPERATION 51
- Stability 52
- 4.3 MOTOR OPERATION 52
- Power/Emergency Stop 52
- SECTION 4 - MACHINE OPERATION 53
- Platform/Ground Select Switch 55
- Motor Activation 55
- 4.4 TRAVELING (DRIVING) 55
- Traveling Forward and Reverse 56
- 4.5 STEERING 58
- 4.6 PLATFORM 58
- Loading From Ground Level 58
- Platform Level Adjustment 59
- Platform Rotation 59
- Jib Swing 59
- 4.7 BOOM 60
- Swinging the Boom 60
- 4.8 GENERATOR 61
- Automatic Operating Mode 61
- Battery Only Operating Mode 61
- 4.9 INVERTER 62
- 4.10 MACHINE FUNCTION SPEEDS 62
- 4.12 SHUT DOWN AND PARK 63
- Tie Down 64
- 5.1 GENERAL 81
- 5.3 EMERGENCY OPERATION 81
- 5.5 MANUAL DESCENT SYSTEM 82
- 5.6 MANUAL SWING OVERRIDE 82
- 6.1 INTRODUCTION 83
- 6.2 OPERATING SPECIFICATIONS 83
- 6-2 – JLG Lift – 3121644 84
- Capacities Tires 85
- Dimensional Data 86
- Torque Specifications 86
- Hydraulic Oil 87
- Critical Stability Weights 88
- Serial Number Locations 89
- 6-8 – JLG Lift – 3121644 90
- 3121644 – JLG Lift – 6-9 91
- 6-10 – JLG Lift – 3121644 92
- 3121644 – JLG Lift – 6-11 93
- 6-12 – JLG Lift – 3121644 94
- 3121644 – JLG Lift – 6-13 95
- 6-14 – JLG Lift – 3121644 96
- 3121644 – JLG Lift – 6-15 97
- 6-16 – JLG Lift – 3121644 98
- Optional On Board Generator 99
- 6.5 TIRES & WHEELS 100
- Tire Inflation 100
- Tire Damage 100
- Tire Replacement 100
- Wheel Replacement 101
- Wheel Installation 101
- 6.6 SUPPLEMENTAL INFORMATION 102
- 3121644 – JLG Lift – 7-1 103
- 7-2 – JLG Lift – 3121644 104
- TRANSFER OF OWNERSHIP 105
- JLG Worldwide Locations 108
Related products and manuals for Special machinery Jlg M400 Operator Manual
(126 pages)
(76 pages)
(120 pages)
(92 pages)
Special machinery Jlg LSS Boom User Manual
(68 pages)
(68 pages)
© 2020, manymanuals.com. All rights reserved. | 2.117 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals